Alaska CDL: Tanker Vehicles Practice Test

Not quite. The answer is both a hazardous materials (H) endorsement and a tank vehicle (N) endorsement.

A tank vehicle (N) endorsement qualifies you to haul liquids or gases. However, if those liquids or gases are classified as hazardous materials, you must also have a hazardous materials (H) endorsement to haul them. To obtain each of these endorsements, you must pass a specialized knowledge test. Note: These days, if you obtain both endorsements, your CDL may include the combined endorsement code X (tank vehicle and HazMat) instead of both H and N.

Not quite. The answer is Rear

Shut-off valves are used in the service and supply air lines at the rear of trailers used to tow other trailers. These valves permit closing off the air lines when another trailer is not being towed. You must check that all shut-off valves are in the open position except the ones at the rear of the last trailer, which must be closed.

Not quite. The answer is there is an even distribution of weight.

Some liquid tanks are divided into several smaller tanks by bulkheads. When loading and unloading the smaller tanks, pay attention to weight distribution. Don’t put too much weight on the front or rear of the trailer.

Not quite. The answer is leaks.

When you inspect your tank vehicle, the most important thing to check for is leaking tanks. It is illegal to knowingly carry liquids or gases in a leaking tank. Check around and underneath the vehicle for any signs of leaks. Also check all tanks, hoses, pipes, and connections for leaks.

Not quite. The answer is joints.

When you're checking the pipes, connections, and hoses of your tank vehicle for leaks, you should pay special attention to joints. Pipe joints are among the weakest points in a piping system. Joints can deteriorate over time and start to leak.

Not quite. The answer is 9,000 gallons.

The average capacity of a DOT-406 or MC-306 fuel delivery truck (often called a "gasoline truck") is 9,000 gallons.

Not quite. The answer is S-cam drum brake.

Foundation brakes are present on each wheel. In North America as of this writing, S-cam drum brakes are much more common than wedge or disc brakes.

Not quite. The answer is you have to press the brake pedal harder than usual to control your speed.

If your brakes begin to fade, you'll notice that you have to depress the brake pedal harder to achieve the same braking effect as before. If your vehicle is so equipped, check the application pressure gauge to see just how much pedal effort you are employing. If the brakes continue to fade, you may not be able to slow down or stop at all.

Not quite. The answer is closed before you drive the vehicle.

To help prevent leaks, close all manhole covers before you drive the vehicle.

Not quite. The answer is Spring brakes (or wheel chocks)

When parking a tank trailer, you should always apply the parking brake. On a modern trailer equipped with air brakes, applying the parking brake control will exhaust air from the brake chambers and cause the spring brakes to come on. However, an old trailer may lack spring brakes and instead use compressed air to set the parking brakes. In this case, you must chock the wheels to prevent the trailer from moving. A leak somewhere in the air braking system may cause the parking brakes to fail eventually.

Not quite. The answer is speed up slightly

The posted speed for a curve may be safe for cars but not for tankers because of their relatively high center of gravity. Tests have shown that a tanker can roll over on a curve when traveling at the posted speed. The safest way to take a curve in a tanker is to slow down before the curve and then accelerate slightly through the curve.

Not quite. The answer is Both of the above are true.

Tank vehicles have a high center of gravity, typically five or six feet above the ground. This makes a tanker top-heavy, which makes it more prone to rollovers than other types of vehicles. Tests have shown that a tank vehicle can roll over at the speed limits posted for curves. To take an upcoming curve safely, slow down well below the posted speed limit.

Not quite. The answer is Upshift.

If your hydraulic brakes fail while you're driving, try pumping the brake pedal to build up enough hydraulic pressure to stop your vehicle. If this fails, downshift to use engine braking and apply the parking brake. Release the parking brake before you lock the wheels. If all else fails, look for an escape route. Head for an escape ramp or an open field and let your vehicle slow to a stop.

Not quite. The answer is If the wheels are skidding, you cannot control the vehicle.

In an emergency, avoid hard braking. Hard braking can lock the wheels, which may cause a skid and loss of control. Instead, use stab braking (unless your vehicle has antilock brakes) or controlled braking.

Not quite. The answer is 20 feet long.

An ISO standard portable tank is a metal tank enclosed in a steel frame. The frame is 19.8556 feet (6.05 meters) long, 7.874 feet (2.40 meters) wide, and either 7.874 feet (2.40 meters) high or 8.374 feet (2.55 meters) high.

Not quite. The answer is Watch gauges and mirrors and use your senses to check for problems: LOOK, LISTEN, and SMELL.

During your trip, you should be watching a number of things, such as your mirrors, gauges, instruments, lights, tires, and cargo. Use several of your senses – sight, hearing, smell, and feel – to detect possible trouble.

Not quite. The answer is your vehicle may jackknife.

If your drive wheels are skidding, it's likely because you applied the brakes too hard and locked the drive wheels. A drive-wheel skid can let the trailer push the tractor sideways, causing a sudden jackknife. To recover from this type of skid, the first thing to do is stop braking. The drive wheels will unlock and start to roll again.

Not quite. The answer is liquids or gases.

According to federal regulations, you need a tank endorsement to drive a tank vehicle that requires you to have a CDL. A tank vehicle is defined as a commercial motor vehicle that transports a bulk cargo of liquid or gas within one or more tanks that are either permanently or temporarily attached to the vehicle. [49 CFR 383.5],

Source: 49 CFR 383.93

Not quite. The answer is receive a citation and be prevented from further driving.

It is illegal to knowingly carry liquids or gases in a leaking tank. If you do, you may receive a citation and be prevented from driving further.

Not quite. The answer is Both of the above

It takes special skills to drive a tanker carrying liquid cargo because of the vehicle's high center of gravity and the possibility that the liquid cargo may surge forward and backward or from side to side. The high center of gravity increases the risk of a rollover. And the liquid surge can push the vehicle dangerously forward or sideways, which can also cause a rollover.