North Dakota CDL: Tanker Vehicles Practice Test

Not quite. The answer is individual tanks over 119 gallons or a total of at least 1,000 gallons.

You must have a tank vehicle (N) endorsement to drive a vehicle with one or more individual tanks over 119 gallons or multiple tanks totaling at least 1,000 gallons.

Not quite. The answer is MC-306 (DOT-406)

MC-306 (DOT-406) cargo tanks carry liquids under very low or no pressure (maximum allowable pressure of 3 psi for MC-306 and 4 psi for DOT-406). The cargo tank has an oval or elliptical cross section and is usually compartmented. These tanks are commonly used to carry gasoline, diesel fuel or fuel oil, and other flammable liquids.

Not quite. The answer is surging.

When a tank is not completely filled, the liquid has room to move around. It can slosh back and forth or side to side. This is called surging.

Not quite. The answer is You should not load a cargo tank completely full.

Some liquids expand significantly when they warm up. To fill a tank with such a liquid, you must leave some room in the tank (called "outage") to take the expansion. Different liquids expand at different rates as the temperature increases. In science, the percentage increase of expansion for a given change in temperature is called the coefficient of thermal expansion. This value depends on the type of liquid. You need to find out how much outage you will need to allow for the type of liquid you'll be hauling.

Not quite. The answer is You should not apply the brakes while turning.

To avoid a crash or other hazard, keep both hands on the steering wheel so you can turn as quickly as possible. However, turn just enough to avoid the hazard. A too-sharp turn risks a skid or rollover. While turning quickly, avoid braking. Braking in a turn can easily lock the wheels and cause a skid.

Not quite. The answer is closed before you drive the vehicle.

To help prevent leaks, close all manhole covers before you drive the vehicle.

Not quite. The answer is can affect the handling of your vehicle.

Liquid surge can greatly affect your vehicle's handling. Surge can push the vehicle in the same direction as the surge. This can be especially hazardous on icy roads, where a truck may be pushed forward a dangerous amount, maybe past a red light into an intersection. On curves, side-to-side surge can cause a rollover even when traction is good.

Not quite. The answer is Rear

Shut-off valves are used in the service and supply air lines at the rear of trailers used to tow other trailers. These valves permit closing off the air lines when another trailer is not being towed. You must check that all shut-off valves are in the open position except the ones at the rear of the last trailer, which must be closed.

Not quite. The answer is baffles.

Baffles are devices that regulate the flow of liquid. In a tank vehicle, baffles are a type of bulkhead with holes through which liquid may flow but with reduced force.

Not quite. The answer is the distance you can see ahead.

No matter what type of motor vehicle you are driving at night (even a passenger car), you must drive at a speed that lets you stop within the range of your headlights. (In the dark, you have no way of knowing what lies beyond the reach of your headlights.) With low beams, you can see ahead only about 250 feet. Yet if you're driving a vehicle with air brakes at 45 mph, your vehicle's stopping distance may be as long as 346 feet. Hence, with low beams at 45 mph, you will not be able to brake in time to avoid a hazard that you see.

Not quite. The answer is the movement of the liquid.

It takes special skills to drive a tanker carrying liquid cargo because of the vehicle's high center of gravity and the possibility that the liquid cargo may surge forward and backward or from side to side. The liquid surge can push the vehicle dangerously forward or sideways, which can cause a rollover. Once a side-to-side surge begins, unless the driver takes action, the tank will keep swaying more and more until the vehicle rolls over.

Not quite. The answer is Set the parking brake and pull forward gently.

The parking brake is meant to keep your vehicle from moving. The best way to test it is to apply the parking brake and then try to pull forward gently. The parking brake should hold your vehicle in place. If you're pulling one or more trailers, test each trailer's parking brakes in the same way.

Not quite. The answer is your vehicle may jackknife.

If your drive wheels are skidding, it's likely because you applied the brakes too hard and locked the drive wheels. A drive-wheel skid can let the trailer push the tractor sideways, causing a sudden jackknife. To recover from this type of skid, the first thing to do is stop braking. The drive wheels will unlock and start to roll again.

Not quite. The answer is speed up slightly

The posted speed for a curve may be safe for cars but not for tankers because of their relatively high center of gravity. Tests have shown that a tanker can roll over on a curve when traveling at the posted speed. The safest way to take a curve in a tanker is to slow down before the curve and then accelerate slightly through the curve.

Not quite. The answer is bulkheads.

Separators that divide a space into liquid-tight compartments are called bulkheads. The tank on a tanker vehicle may have bulkheads to divide the tank into separate compartments.

Not quite. The answer is be within 25 feet of the tank.

The person in charge of loading and unloading a cargo tank must be sure a qualified person is always watching. This person watching the loading or unloading must be alert, have a clear view of the cargo tank, be within 25 feet of the tank, know of the hazards of the materials involved, know the procedures to follow in an emergency, be authorized to move the cargo tank and able to do so.

Not quite. The answer is a rollover.

A side-to-side surge exerts lateral (sideways) forces on the tank. Once a side-to-side surge begins, unless the driver takes action, the tank will keep swaying more and more until the vehicle rolls over.

Not quite. The answer is Wet roads can double the stopping distance at any speed.

To control surge, know the stopping distance of your vehicle and brake far in advance of a stop whenever possible. Bear in mind that your vehicle's stopping distance on wet roads will be about double its stopping distance on dry roads.

Not quite. The answer is Both of the above

It takes special skills to drive a tanker carrying liquid cargo because of the vehicle's high center of gravity and the possibility that the liquid cargo may surge forward and backward or from side to side. The high center of gravity increases the risk of a rollover. And the liquid surge can push the vehicle dangerously forward or sideways, which can also cause a rollover.

Not quite. The answer is a high center of gravity.

It takes special skills to drive a tanker carrying liquid cargo because of the vehicle's high center of gravity and the possibility that the liquid cargo may surge forward and backward or from side to side. Much of a loaded tanker's weight is carried five or six feet above the ground. This makes a tanker top-heavy, which makes it more prone to rollovers than other types of vehicles. Tests have shown that a tank vehicle can roll over at the speed limits posted for curves. The safest way to take a curve in a tanker is to slow down well below the posted speed limit before you enter the curve.